Skip to main navigation menu Skip to main content Skip to site footer
Plant Science Today (PST)

Research Articles

Vol. 12 No. 3 (2025)

Effect of cabinet tray drying method on physicochemical, nutritional and antioxidant status of dragon fruit (Hylocereus polyrhizus) powder: A comparative analysis on laboratory and commercial market sample

DOI
https://doi.org/10.14719/pst.7265
Submitted
18 January 2025
Published
01-08-2025 — Updated on 16-08-2025
Versions

Abstract

Dragon fruit (Hylocereus polyrhizus) belonging to the Cactaceae family, is gaining popularity in India as a minor tropical fruit crop. However, due to high perishability associated with dragon fruits, drying is one of the most effective viable methods for its long-term preservation. Spray and Drum drying are the two major expensive methods recognized for converting dragon fruit into powder. To overcome this, a low-cost tray drying process was attempted to produce dragon fruit powder with minimal additive incorporation and optimal free-flowing properties. The physico-chemical properties, mineral content and antioxidant activity of the laboratory-produced powder were evaluated and compared with a commercially available spray-dried red dragon fruit powder. The parameters analyzed included moisture content, water activity, whiteness index, total sugars, ascorbic acid, protein, total phenols, total betalains, antioxidant activity (Ferric Reducing Antioxidant Power; FRAP assay) and mineral content. Results of the data revealed that the laboratory sample demonstrated superior quality, with higher total sugars (26.69 %), protein (1.97 %), total phenols (576.56 mg GAE/100 g), total betalains (96.93 mg BCE/100 g) and FRAP activity (120.80 mg AEAC/100 g). The powder also exhibited the desirable storage properties such as lower moisture content (0.98 %), lower water activity (0.270) and low whiteness index (6.030). Experimental findings revealed that the laboratory produces dragon fruit powder was not only tagged as lower in production costs but also had significantly higher nutrient content, phytochemicals and antioxidant levels compared to the commercial sample.

References

  1. 1. Ow RPS. Isolation, purification and characterization of natural red pigment from dragon fruit (Hylocereus polyrhizus) Doctoral dissertation, University of Malaya. 2012.
  2. 2. Septiansyah MR, Wijirahayu S, Nugroho PZ, Barickly LR, Agatha C, Hensya CZFP. An antioxidant potential and cholesterol-lowering effects of dragon fruit peel. Forum for University Scholars in Interdisciplinary Opportunities and Networking. 2025;1(1):273-81.
  3. 3. Wakchaure GC, Kumar S, Meena KK, Rane J, Pathak H. Dragon fruit cultivation in India: Scope, constraints and policy issues. NIASM Tech. Bull.. 2021;27:1-47.
  4. 4. Wakchaure GC, Choudhari JD, Kukde RB, Reddy KS. Postharvest technology of dragon fruit. Tech Bull. 2023;41:45.
  5. 5. Lane JH, Eynon L. Methods for determination of reducing and non-reducing sugars. J Sci. 1923;42:32-7.
  6. 6. Lowry OH, Rosebrough NJ, Farr AL, Randall RJ. Protein measurement with the Folin phenol reagent. J Biol Chem. 1951;193(1):265-75. https://doi.org/10.1016/S0021-9258(19)52451-6
  7. 7. Sadasivam S, Manickam A. Biochemical methods for agricultural sciences. Wiley Eastern Ltd. 1992.
  8. 8. Singleton VL, Orthofer R, Lamuela-Raventós RM. Analysis of total phenols and other oxidation substrates and antioxidants by means of Folin-Ciocalteu reagent. Methods Enzymol. 1999;299:152-78. https://doi.org/10.1016/S0076-6879(99)99017-1
  9. 9. AOAC. Official methods of analysis. 17th ed. Washington, DC: The Association of Official Analytical Chemists.2000.
  10. 10. Choo WS, Yong WK. Antioxidant properties of two species of Hylocereus fruits. Adv Appl Sci Res. 2011;2(3):418-25.
  11. 11. Sandate-Flores L, Rodriguez-Rodriguez J, Calvo-Segura S, Mayorga-Martinez A, Parra-Saldivar R, Chuck-Hernandez C. Evaluation of different methods for betanin quantification in pitaya (Stenocereus spp.). Agro Food Ind Hi Tech. 20161;27:20-5.
  12. 12. Benzie IFF, Strain JJ. The ferric reducing ability of plasma (FRAP) as a measure of “antioxidant power”: The FRAP assay. Anal Biochem. 1996;239(1):70-6. https://doi.org/10.1006/abio.1996.0292
  13. 13. Jaya S, Das H. Accelerated storage, shelf life and color of mango powder. Journal of Food Processing and Preservation. 2005;29(1):45-62.
  14. 14. Santos D, Maurício AC, Sencadas V, Santos JD, Fernandes MH, Gomes PS. Spray drying: an overview. Biomaterials-Physics and Chemistry-New Edition. 2018;2:9-35.
  15. 15. Cano-Chauca M, Stringheta PC, Ramos AM, Cal-Vidal J. Effect of the carriers on the microstructure of mango powder obtained by spray drying and its functional characterization. Innovative Food Science & Emerging Technologies. 2005;6(4):420-8.
  16. 16. Fontana AJ. Understanding the importance of water activity in food. Cereal foods world. 2000;45(1):7-10.
  17. 17. Fazaeli M, Emam-Djomeh Z, Ashtari AK, Omid M. Effect of spray drying conditions and feed composition on the physical properties of black mulberry juice powder. Food and bioproducts processing. 2012;90(4):667-75.
  18. 18. Shishir MR, Chen W. Trends of spray drying: A critical review on drying of fruit and vegetable juices. Trends in Food Science & Technology. 2017;65:49-67.
  19. 19. Zhang L, Zeng X, Fu N, Tang X, Sun Y, Lin L. Maltodextrin: A consummate carrier for spray-drying of xylooligosaccharides. Food Res Int. 2018;106:383-93. https://doi.org/10.1016/j.foodres.2018.01.004
  20. 20. Caliskan G, Dirim SN. The effects of the different drying conditions and the amounts of maltodextrin addition during spray drying of sumac extract. Food Bioprod Process. 2013;91(4):539-48. https://doi.org/10.1016/j.fbp.2013.06.004
  21. 21. Grabowski JA, Truong VD, Daubert CR. Spray drying of amylase hydrolyzed sweet potato puree and physicochemical properties of powder. J Food Sci. 2006;71:E209-E217. https://doi.org/10.1111/j.1750-3841.2006.00036.x
  22. 22. Saeed AR, Tahle MA, Tlay RH. Effect of drying agents on quality parameters of lyophilized persimmon purée powder. Foods and Raw materials. 2024;12(2):256-63.
  23. 23. Kha TC, Nguyen MH, Roach PD. Effects of spray drying conditions on the physicochemical and antioxidant properties of the Gac (Momordica cochinchinensis) fruit aril powder. J Food Eng. 2010;98(3):385-92. https://doi.org/10.1016/j.jfoodeng.2010.01.016
  24. 24. Ghorband AS, Joshi BH, Bhatt HG. Studies on physicochemical and nutritional properties of dragon fruit (Hylocereus polyrhizus). Journal of Pharmacognosy and Phytochemistry. 2023;12(6):223-6. https://doi.org/10.22271/phyto.2023.v12.i6c.14785
  25. 25. Ariffin AA, Bakar J, Tan CP, Rahman RA, Karim R, Loi CC. Essential fatty acids of pitaya (dragon fruit) seed oil. Food Chem. 2009;114(2):561-4. https://doi.org/10.1016/j.foodchem.2008.09.108
  26. 26. Herbach KM, Rohe M, Stintzing FC, Carle R. Structural and chromatic stability of purple pitaya (Hylocereus polyrhizus [Weber] Britton & Rose) betacyanins as affected by the juice matrix and selected additives. Food Res Int. 2006;39(6):667-77. https://doi.org/10.1016/j.foodres.2006.01.004
  27. 27. Vinod BR, Ramachandra NK, Kirankumar G, Deepa T, Patil SN. Physicochemical characteristics of microencapsulated red-fleshed dragon fruit juice powder through spray drying. Biol Forum. 2021;13(3):86-94.
  28. 28. Jiménez-Aguilar DM, Ortega-Regules AE, Lozada-Ramírez JD, Pérez-Pérez MCI, Vernon-Carter EJ, Welti-Chanes J. Color and chemical stability of spray-dried blueberry extract using mesquite gum as wall material. J Food Compos Anal. 2011;24(6):889-94. https://doi.org/10.1016/j.jfca.2011.04.012
  29. 29. Nthimole CT, Kaseke T, Fawole OA. Micro-encapsulation and characterization of anthocyanin-rich raspberry juice powder for potential applications in the food industry. Processes. 2022;10(5):1038. https://doi.org/10.3390/pr10051038
  30. 30. Ileana TMK, Guadalupe GVT, Francisco TV, Ismael ORG. Spray drying microencapsulation of purple cactus pear (Opuntia ficus indica) peel extract and storage stability of bioactive compounds. Emirates J Food Agric. 2019;31(12):958-68. https://doi.org/10.9755/ejfa.2019.v31.i12.2046
  31. 31. Sagar VR, Kumar R. Effect of drying treatments and storage stability on quality characteristics of bael powder. J Food Sci Technol. 2014;51:2162-8. https://doi.org/10.1007/s13197-012-0727-7
  32. 32. Tze NL, Han CP, Yusof YA, Ling CN, Talib RA, Taip FS, et al. Physicochemical and nutritional properties of spray-dried pitaya fruit powder as a natural colorant. Food Sci Biotechnol. 2012;21:675-82. https://doi.org/10.1007/s10068-012-0088-z
  33. 33. Mishra P, Rai GK, Mahanta CL. Process standardization for development of spray-dried lemon juice powder and optimization of amla-lemon based RTS (readytoserve) drink using response surface methodology. Journal of Food Processing and Preservation. 2015;39(6):1216-28. https://doi.org/10.1111/jfpp.12338
  34. 34. Aswathy S, Suresha GJ, Sneha N, Sadananda GK. Microencapsulation of lycopene rich cherry tomato powder using spray drying. IJCS. 2019;7(1):2270-7.

Downloads

Download data is not yet available.